ISUZU Amigo/Pick-ups/Rodeo/Trooper 1981-1996

Blower Motor

Print

REMOVAL & INSTALLATION



See Figures 1, 2, 3 and 4



Click image to see an enlarged view

Fig. Fig. 1: Heater blower assembly-except Hombre



Click image to see an enlarged view

Fig. Fig. 2: Heater blower assembly-Hombre



Click image to see an enlarged view

Fig. Fig. 3: Removing the heater blower retaining screw under the dash panel-1991 Trooper shown



Click image to see an enlarged view

Fig. Fig. 4: Removing the heater blower assembly-1991 Trooper shown

Except Hombre

The blower motor is located under the instrument panel next to the right side kick panel.

  1. Disconnect the negative (-) battery cable.
  2.  
  3. Remove the instrument panel trim panel, if so equipped.
  4.  
  5. Disconnect the blower motor wiring.
  6.  
  7. Remove the retaining screws and motor assembly.
  8.  
  9. Remove the cage retaining clip and cage from the motor.
  10.  

To install:
  1. Install the cage onto the motor and install the clip.
  2.  
  3. Install the motor, retaining screws and wiring connector.
  4.  
  5. Connect the battery cable and check operation.
  6.  

Hombre

The blower motor is located inside the engine compartment on the fire wall. The blower relay is attached to the blower assembly. The resistor assembly is located under the outer blower case cover.

  1. Disconnect the negative (-) battery cable.
  2.  
  3. Disconnect the PCM. If necessary remove the PCM.
  4.  
  5. Remove the coolant reservoir.
  6.  
  7. Disconnect the motor harness connector.
  8.  
  9. Remove the retaining screws and pull the motor and cage out of the housing.
  10.  
  11. Remove the retaining clip or nut and remove the cage from the motor.
  12.  

To install:
  1. Install the cage onto the motor and install the clip or retaining nut.
  2.  
  3. Install the motor and tighten the retaining screws.
  4.  
  5. Install the coolant reservoir.
  6.  
  7. Install the PCM.
  8.  
  9. Connect the wiring and battery cable. Remember to check the coolant level.
  10.  

 
label.common.footer.alt.autozoneLogo