Mitsubishi Pick-ups and Montero 1983-1995 Repair Guide

Component Locations

Print

1983-89 MONTERO





Main Fusible Links: 1983-87 models at the positive battery terminal; 1988-89 models at bottom of small terminal box near the battery.
 
Sub-links: at bottom of small terminal box near battery.
 
Fusebox: mounted in left-hand side end panel of dashboard.
 
Special fuses not in the fusebox: 1983-89 4-cylinder models' headlight high beam indicator fuse located in harness behind left headlight. 1987-88 models' air conditioner fuse mounted on evaporator case; 1989 model's rear defogger link in harness near sub-link, V6 headlight circuit in wiring harness at driver's side firewall, sunroof fuse above right dash speaker, power door lock fuse in wire harness running just above steering column behind dashboard, rear air conditioner (if so equipped) fuse on blower assembly under right dashboard.
 
Turn Signal and Hazard Flasher Relay: separate units mounted under the dash and above the left kick panel. (The hazard flasher is round.)
 

1990-95 MONTERO



See Figures 1, 2 and 3



Main Fusible Links: one at positive battery terminal, one in small terminal box near the battery.
 
Fusebox: mounted under the left-hand side dashboard, next to the lower speaker.
 
Special fuses not in the fusebox: dedicated fuse No. 9 located on relay board, just outside of the fuse box.
 
Turn Signal and Hazard Flasher Relay, Overdrive Relay, Power Window Relay, Defogger Relay, and Rear Intermittent Wiper Relay: separate units mounted under the dash, next to the fuse box and the left-hand, lower speaker.
 
Tail Light Relay, Condenser Fan Motor Relay, A/C Compressor Relay, Generator Relay, and Headlight Relay: separate units mounted in the small terminal box next to the battery.
 



Click image to see an enlarged view

Fig. Fig. 1: Fusible link, fuse and Ignition Off Draw (IOD)/storage connector locations-1992-95 Monteros



Click image to see an enlarged view

Fig. Fig. 2: Relay locations-1992-95 Monteros



Click image to see an enlarged view

Fig. Fig. 3: Relay locations (continued)-1992-95 Monteros

PICK-UP



See Figures 4 and 5



Main Fusible Links: 1983-89 models-two at the positive battery terminal; 1990-95 models-one at the positive battery terminal.
 
Sub-links: 1983-86 models have none; 1987-95 models-one on the left inner fender panel.
 
Fusebox: under left dashboard.
 
Special fuses not in the fusebox: none
 
Turn Signal and Hazard Flasher Relay (1983-95 models), Seat Belt Warning Time Relay (1992-95 models), Power Window Relay (1992-95 models), Starter Relay (1992-95 models), Starter Unlock Relay (1992-95 models): combined unit on relay board near the fusebox.
 
Vacuum Pump Relay (1992-95 models): mounted in the back, right-hand corner of the engine compartment.
 
A/C Compressor Clutch Relay (1992-95 models): mounted on the left, inner fender, next to the sub-fusible link.
 
Central Door Lock Control Relay (1992-95 models): mounted in the front of the right-hand door, under the door panel trim.
 
Power Window Control Relay (1992-95 models): mounted in the front left-hand door, under the door panel trim.
 



Click image to see an enlarged view

Fig. Fig. 4: Fusible link, fuse and Ignition Off Draw (IOD)/storage connector locations-1987-95 Pick-up trucks



Click image to see an enlarged view

Fig. Fig. 5: Relay locations-1987-95 Pick-up trucks

 
label.common.footer.alt.autozoneLogo