MonteCarlo 2000

Low Oil Pressure Warning Sensor

Print

Description & Operation



Specific to:

Buick Century 1997-2000

Buick Regal 1997-2000

Chevrolet Lumina 1997-2000

Chevrolet Monte Carlo 1997-2000

Oldsmobile Cutlass Supreme 1997

Oldsmobile Intrigue 1998-2000

Pontiac Grand Prix 1997-2000

The oil pressure warning indicator switch (also called a sender unit) receives battery voltage with the ignition switch in the RUN, BULB TEST or START position. The instrument cluster will turn the indicator ON during engine startup for a bulb check. The indicator is grounded by the fuel pump/oil pressure switch with a low oil pressure condition.

Removal & Installation



Specific to:

Buick Century 1997-2000

Buick Regal 1997-2000

Chevrolet Lumina 1997-2000

Chevrolet Monte Carlo 1997-2000

Oldsmobile Cutlass Supreme 1997

Oldsmobile Intrigue 1998-2000

Pontiac Grand Prix 1997-2000



Click image to see an enlarged view

Fig. This oil pressure warning switch is located on the side of the engine block, near the oil filter-3.1L engine shown, 3.4L (VIN X) engine similar



Click image to see an enlarged view

Fig. This oil pressure warning switch is located on the oil filter adapter assembly-3.8L engine



Click image to see an enlarged view

Fig. Oil pressure warning switch location-3.4L (VIN E) engine



Click image to see an enlarged view

Fig. Location of the oil pressure warning switch location-3.5L (VIN H) engine

  1. Raise and safely support the vehicle.
  2.  
  3. Drain the engine oil into a suitable container.
  4.  
  5. Unplug the electrical connector from the oil pressure warning switch.
  6.  
  7. Unthread and remove the switch.
  8.  

To install:

  1. Install the oil pressure warning switch and tighten securely.
  2.  
  3. Plug in the electrical connector.
  4.  
  5. Lower the vehicle.
  6.  
  7. Add the proper type and amount of engine oil.
  8.  

Testing



"Oil" Pressure Indicator Not On, With Ignition In On Position, Engine Not Running

Specific to:

Buick Century 1997-2000

Buick Regal 1997-2000

Chevrolet Lumina 1997-2000

Chevrolet Monte Carlo 1997-2000

Oldsmobile Cutlass Supreme 1997

Oldsmobile Intrigue 1998-2000

Pontiac Grand Prix 1997-2000

  1. Disconnect the fuel pump/engine oil pressure indicator switch.
  2.  
  3. Connect a fused (3 Amp) jumper between terminal A (tan wire) and ground. With the ignition switch in the ON position, is the "OIL" indicator ON-
  4.  
  5. If yes, check for a poor connection at the switch terminal. If okay, replace the switch.
  6.  
  7. If no, look for an open between the instrument cluster connection and the oil pressure switch terminal. If okay, the instrument cluster may need to be serviced.
  8.  

"Oil" Pressure Indicator Stays On, With Engine Running And Normal Oil Pressure

Specific to:

Buick Century 1997-2000

Buick Regal 1997-2000

Chevrolet Lumina 1997-2000

Chevrolet Monte Carlo 1997-2000

Oldsmobile Cutlass Supreme 1997

Oldsmobile Intrigue 1998-2000

Pontiac Grand Prix 1997-2000

  1. Disconnect the fuel pump/engine oil pressure indicator switch at the engine.
  2.  
  3. With the ignition switch in the ON position, and with the engine running, is the "OIL" indicator ON-
    1. If not, replace the indicator switch.
    2.  
    3. If the "OIL" indicator is still ON, check the circuit for a short to ground somewhere between the instrument cluster connection and the oil pressure switch terminal A. If okay, the instrument cluster may need to be serviced.
    4.  

  4.  

 
label.common.footer.alt.autozoneLogo