Suzuki Aerio, Verona 2002-06

Removal & Installation

Print


NOTE
The fuel filter is either on the left side of the firewall or next to the fuel pump near the left side of the fuel tank.

  1. Before servicing the vehicle, refer to the Precautions Section.
  2.  
  3. Relieve the fuel system pressure.
  4.  
  5. Remove or disconnect the following:

    Negative battery cable
     
    Fuel filler cap
     
    Fuel lines from the fuel filter
     
    Fuel filter from the bracket
     

  6.  

To install:

  1. Install or connect the following:

    Fuel filter to the bracket
     
    Fuel lines to the fuel filter
     
    Fuel filler cap
     
    Negative battery cable
     

  2.  
  3. Start the engine and check for leaks.

    Click image to see an enlarged view

    Fig. Using an open end wrench to push the quick disconnect coupler sleeves back-5 cylinder models shown

  4.  


CAUTION
The fuel system pressure must be relieved before disconnecting any fuel lines. Failure to do so may result in personal injury.

  1. Before servicing the vehicle, refer to the Precautions Section.
  2.  
  3. Properly relieve the fuel system pressure.
  4.  
  5. Disconnect the negative battery cable.
  6.  
  7. Place a container under the fuel filter.
  8.  
  9. Remove or disconnect the following:
    CAUTION
    A small amount of fuel may be released after the fuel hose is disconnected. Cover the hose and pipe with a shop towel.



    Fuel filter protector
     
    Rear fuel feeding tube from the fuel filter
     



    Rear fuel filter tube from the fuel filter
     
    Fuel filter mounting bracket bolt and remove the fuel filter from the vehicle
     
    Fuel filter from the mounting bracket
     

  10.  

To install:

  1. Install or connect the following:

    Fuel filter on the mounting bracket
     
    Fuel filter in position on the underside of the vehicle. Secure with mounting bolt.
     
    Rear fuel filter tube to the fuel filter
     
    Rear fuel feeding tube to the fuel filter
     
    Fuel filter protector
     
    Negative battery cable
     

  2.  
  3. With the ignition ON and the engine OFF check for leaks.
  4.  

The fuel filter on the Verona is located under the vehicle along the fuel line.

The fuel filter for Aerio models is an integral component of the in-tank fuel pump assembly. Refer to the Fuel Pump Removal procedure later in this section.

 
label.common.footer.alt.autozoneLogo